Effects of crop residues for animal consumption and soil enhancement on the electricity generation potential of residues: A case study of Sawla-Tuna-Kalba district, Ghana

Augustine Awaafo, Edward A. Awafo, Meisam Mahdavi, David Vera, Gilbert Ayine Akolgo, Emmanuel Amankwah, Francisco Jurado

Abstract


Many studies have estimated the potential of crop residues for energy generation globally and recognized its great potential, especially in rural areas where on-grid electricity is uneconomical. However, crop residues have other equally important uses as animal feed and as mulch for soil enhancement, especially in rural farming communities. Nevertheless, most of the known studies have neglected the estimation of the quantity of crop residues that will be required for feeding animals and also for the enhancement of soil through mulching in their energy potential estimation from crop residues. Neglecting these two important uses can lead to the over-exploitation of the residues for energy generation at the expense of conservation agriculture practices as well as depriving animals of quality feed which can lead to low crop yield and animal production, with the ability to cause hunger and poverty. This study has assessed the potential of electricity generation from agricultural residues in the Sawla-Tuna-Kalba district of Ghana using gasification technology, taking cognizance of the proportion of residues needed for animal consumption and soil enhancement. The results of the study indicate that out of the 207 646.22 t of residues that can be generated from maize, yam, cassava, millet, sorghum, and groundnut, 26 830.36 t (representing 13%) will be required by sheep, goats, and cows for consumption, and 13 936.17 t (representing 7%) will be required for mulching soils where the crops are planted. Also, it was found that a total of 592.17 MW∙h of electricity can be generated from crop residues without animal consumption and soil enhancement needs, while 461.89 MW∙h could be generated from the residues, considering animal feed and soil enhancement. This study has indicated that it is not enough to consider soil enhancement and animal feeding in agricultural biomass power generation through recovery factors without the exact quantification of residues required for these purposes since this can lead to a violation of conservation agricultural practice. Hence, it is concluded that the proper estimation of residues required for soil enhancement needs and animal feeding must be considered in the estimation of crop residues available for electricity generation following the method proposed in this study. It is further concluded from this study that, the proper utilization of crop residues serve as an important resource for meeting the electricity demand of the inhabitants in the study location without compromising on the residues that will be required for the consumption of all the animals in the location as well as for enhancement of the soil.
Key words: animal feed; crop residue; electricity generation; soil enhancement
DOI: 10.25165/j.ijabe.20241704.8693

Citation: Awaafo A, Awafo Edward A., Mahdavi M, Vera D, Akolgo G A, Amankwah E, et al. Effects of crop residues for animal consumption and soil enhancement on the electricity generation potential of residues: A case study of Sawla-Tuna-Kalba district, Ghana. Int J Agric & Biol Eng, 2024; 17(4): 276–287.

Keywords


animal feed; crop residue; electricity generation; soil enhancement

Full Text:

PDF

References


IPCC. Climate change 2022: Impacts, adaptation and vulnerability. 2022; Available: https://www.ipcc.ch/report/ar6/wg2/. Accessed on: [2023-05-01].

UN. The 17 SDG’S, united nations sustainable development goals. 2020; Available: https://sdgs.un.org/goals. Accessed on: [2023-04-18].

Abas N, Kalair A, Khan N. Review of fossil fuels and future energy technologies. Futures, 2015; 69: 31–49.

IEA. Key world energy statistics 2021. 2021; Available: https://www.iea.org/reports/key-world-energy-statistics-2021. Accessed on: [2023-05-01]

Azni M A, Khalid R M, Hasran U A, Kamarudin S K. Review of the effects of fossil fuels and the need for a hydrogen fuel cell policy in Malaysia. Sustain, 2023; 15（5）: 4033.

Cronin J, Anandarajah G, Dessens O. Climate change impacts on the energy system : A review of trends and gaps. Climatic Change, 2018; 151: 79–93.

KFW, GIZ, and IRENA. The renewable energy transition in africa: powering access, resilience and prosperity. 2020; Available: https://www.irena.org/-/media/Files/IRENA/Agency/Publication/2021/March/Renewable_Energy_Transition_Africa_2021.pdf. Accessed on: [2023-04-18].

Shirzad M, Panahi H K S, Dashti B B, Rajaeifar M A, Aghbashlo M, Tabatabaei M. A comprehensive review on electricity generation and GHG emission reduction potentials through anaerobic digestion of agricultural and livestock/slaughterhouse wastes in Iran. Renew Sustain Energy Rev, 2019; 111: 571–594.

Aghbashlo M, Mandegari M, Tabatabaei M, Farzad S, Mojarab Soufiyan M, Görgens J F. Exergy analysis of a lignocellulosic-based biorefinery annexed to a sugarcane mill for simultaneous lactic acid and electricity production. Energy, 2018; 149: 623–638.

Mensah T N O, Oyewo A S, Breyer C. The role of biomass in sub-Saharan Africa’s fully renewable power sector – The case of Ghana. Renew Energy, 2021; 173: 297–317.

IRENA, DBFZ. Stecher K, Brosowski A, Thrän D. Biomass potential in Africa. 2013; Available: https://www.irena.org//media/Files/IRENA/Agency/Publication/2013/IRENA-DBFZ_Biomass-Potential-in-Africa.pdfca. Accessed on: [2023-04-18].

Lynd L R, Sow M, Chimphango A F, Cortez L A, Brito Cruz C H, Elmissiry M, et al. Bioenergy and African transformation. Biotechnology for Biofuels, 2015; 8: doi: 10.1186/s13068-014-0188-5.

Ambali A, Chirwa P W, Chamdimba O, van Zyl W H. A review of sustainable development of bioenergy in Africa: An outlook for the future bioenergy industry. Sci Res Essays, 2011; 6（8）: 1697–1708.

Awaafo A, Awafo E A, Mahdavi M, Akolgo G, Jurado F, Vera D et al. Crops production and the contribution of agricultural biomass power generation to Africa’s clean energy transition: Analysis of trends from 1990 to 2021. Biomass and Bioenergy, 2024; 186: 107244.

Mohammed Y S, Mustafa M W, Bashir N, Ogundola M A, Umar U. Sustainable potential of bioenergy resources for distributed power generation development in Nigeria. Renew Sustain Energy Rev, 2014; 34: 361–370.

Khatiwada D, Seabra J, Silveira S, Walter A. Power generation from sugarcane biomass - A complementary option to hydroelectricity in Nepal and Brazil. Energy, 2012; 48（1）: 241–254.

Beeharry R P. Extended sugarcane biomass utilisation for exportable electricity production in Mauritius. Biomass and Bioenergy, 1996; 11: （6）: 441–449.

Energy Commission. 2021 energy outlook for Ghana: Demand and supply outlook. 2021; Available: http://www.energycom.gov.gh/planning/data-%0Acenter/energy-outlook-for-ghana?download=120:energy-outlook-for-ghana-2021. Accessed on: [2023-04-18].

Azasi D V, Offei F, Kemausuor F, Akpalu L. Biomass and bioenergy bioenergy from crop residues : A regional analysis for heat and electricity applications in Ghana. Biomass and Bioenergy, 2020; 140: 105640.

Odoi-Yorke F, Osei L K, Gyamfi E, Adaramola M S. Assessment of crop residues for off-grid rural electrification options in Ghana. Sci African, 2022; 18.

No. November 2015. Ministry of Power. National Renewable Energy Action Plans （ NREAPs ） （Ghana ）. 2020.

MoEn, EC, UNDP, NPC. Ghana renewable energy master plan. 2019; Available: http://energycom.gov.gh/files/Renewable-Energy-Masterplan-February-2019.pdf. Accessed on: [2023-04-18].

ACT 832. Renewable Energy. Ghana: The Parliament of Ghana, 2011. Available: https://energycom.gov.gh/files/RENEWABLE%20ENERGY%20ACT%202011%20（ACT%20832）.pdf. Accessed on: [2023-04-18].

ACT 1045. Renewable Energy （Amendment） Act, 2020. Available: https://ir.parliament.gh/bitstream/handle/123456789/2062/RENEWABLE%20ENERGY%20（AMENDMENT）%20ACT,%202020%20（ACT%201045）.pdf. Accessed on: [2023-04-18].

Afrane S, Ampah J D, Jin C, Liu H F, Aboagye E M. Techno-economic feasibility of waste-to-energy technologies for investment in Ghana : A multicriteria assessment based on fuzzy TOPSIS approach. J Clean Prod, 2021; 318: 128515.

Kemausuor F, Adaramola M S, Morken J. A review of commercial biogas systems and lessons for Africa. Energies, 2018; 11（11）: 2984.

Kemausuor F, Kamp A, Thomsen S T, Bensah E C, Stergård H. Assessment of biomass residue availability and bioenergy yields in Ghana. Resour Conserv Recycl, 2014; 86: 28–37.

Manandhar A, Mousavi-Avval S H, Tatum J, Shrestha E, Nazemi P, Shah A. Solid biofuels. In: Murthy G S, Gnansounou E, Khanal S K, Pandey A, （Ed.） Biomass, Biofuels, Biochem. Amsterdam: Elsevier. 2021; pp.343–370.

IRENA, Renewable Energy Statistics 2020. Renewable hydropower （including mixed plants）. 2020; Available: https://www.irena.org/publications/2020/Jul/Renewable-energy-statistics-2020. Accessed on: [2023-04-18].

Ezealigo U S, Ezealigo B N, Kemausuor F, Achenie L E K, Onwualu A P. Biomass valorization to bioenergy: Assessment of biomass residues’ availability and bioenergy potential in Nigeria. Sustain, 2021; 13（24）: 13806.

Mohammed Y S, Mokhtar A S, Bashir N, Saidur R. An overview of agricultural biomass for decentralized rural energy in Ghana. Renew Sustain Energy Rev, 2013; 20: 15–25.

Awafo E A, Akolgo G A, Awaafo A. Assessment of agricultural residue potential for electrification of off-grid communities in the Sawla-Tuna-Kalba District of Ghana. In Press. doi: 10.21203/rs.3.rs-2052578/v1.

Arranz-Piera P, Kemausuor F, Addo A, Velo E. Electricity generation prospects from clustered smallholder and irrigated rice farms in Ghana. Energy, 2017; 121: 246–255.

Osei I, Addo A, Kemausuor F. Crop residues utilisation for renewable energy generation in Ghana : Review of feedstocks assessment approach, conversion technologies and challenges. Ghana Journal of Technology, 2021; 5: 29–42.

Jekayinfa S O, Scholz V. Potential availability of energetically usable crop residues in Nigeria. Energy Sources, Part A: Recovery, Utilization, and Environmental Effects, 2009; 31（8）: 687–697.

Pastori M, Udias A, Cattaneo L, Moner-Girona M, Niang A, Carmona-Moreno C. Bioenergy potential of crop residues in the Senegal river basin: A cropland–energy–water-environment nexus approach. Sustain, 2021; 13（19）: 11065.

Marrison C I, Larson E D. A preliminary analysis of the biomass energy production potential in africa in 2025 considering projected land needs for food production. Biomass and Bioenergy, 1996; 10（5-6）: 337–351.

Massuque J, Matavel C, Trugilho P F. Outlook for the biomass energy sector in Mozambique: Policies and their challenges. J Energy in Southern Africa, 2021; 32（4）. doi: .

Ayamga E A, Kemausuor F, Addo A. Resource., conservation and recycling technical analysis of crop residue biomass energy in an agricultural region of Ghana. Resources, Conserv Recycl, 2015; 96: 51–60.

Seglah P A, Wang Y J, Wang H Y, Gao C Y, Bi Y Y. Sustainable biofuel production from animal manure and crop residues in Ghana. Energies, 2022; 15（16）: 5800.

Vaish B, Srivastava V, Singh P K, Singh P, Singh R P, Wood H. Energy and nutrient recovery from agro-wastes : Rethinking their potential possibilities. Environ Eng Res, 2020; 25（5）: 623–637.

Gojiya A, Deb D, Iyer K K R. Feasibility study of power generation from agricultural residue in comparison with soil incorporation of residue. Renew Energy, 2019; 134: 416–425.

Sarkar S, Skalicky M, Hossain A, Brestic M, Saha S, Garai S, et al. Management of crop residues for improving input use efficiency and agricultural sustainability. Sustainability, 2020; 12（23）.

Kamusoko R, Jingura R M, Parawira W, Chikwambi Z. Strategies for valorization of crop residues into biofuels and other value-added products. Biofuels, Bioprod Biorefining, 2021; 15（6）: 1950–1964.

Govaerts B, Sayre K D, Deckers J. Stable high yields with zero tillage and permanent bed planting? Field Crops Research, 2005; 94（1）: 33–42.

Kassam A, Friedrich T, Shaxson F, Pretty J. The spread of conservation agriculture: Justification, sustainability and uptake. Int J Agric Sustain, 2009; 7（4）: 292–320.

Gatzweiler F W, von Braun J. Technological and institutional innovations for marginalized smallholders in agricultural development. London: Springer. 2016; 435 p.

Pulina G, Avondo M, Molle G, Francesconi A H D, Atzor A S, Cannas A. Nutrient requirements of small ruminants: sheep, goats, cervids, and new world camelids. Washington DC: The National Academies Press. 2007; 362 p. Available: https://www.scielo.br/j/rbz/a/h8NRWC9YYj5jXvzcLcKZbBF/?format=pdf. Accessed on: [2023-04-18].

Buchholz T, Da Silva I. Potential of distributed wood-based biopower systems serving basic electricity needs in rural Uganda. Energy for Sustainable Development, 2010; 14（1）: 56–61.

Kumar A, Ogita S, Yau Y Y. Biofuels: Greenhouse gas mitigation and global warming. Springer: Jaipur, India. 2018; 432 p.

Zoungrana L, Sidibé S D S, Herman B, Coulibaly Y, Jeanmart H. Design of a gasification reactor for manufacturing and operation in West Africa. Designs, 2021; 5（4）.

Indrawan N, Kumar A, Moliere M, Sallam K A, Huhnke R L. Distributed power generation via gasification of biomass and municipal solid waste: A review. J Energy Inst, 2020; 93（6）: 2293–2313.

Eliasu A, Derkyi N S A, Gyamfi S. Techno-economic analysis of municipal solid waste gasification for electricity generation. Int J Energy Econ Policy, 2022; 12（1）: 342–348.

Diyoke C, Idogwu S, Ngwaka U C. An economic assessment of biomass gasification for rural electrification in Nigeria. Int J Renew Energy Technol Res, 2014; 3（1）: 1–17.

Sobamowo G M, Ojolo S J. Techno-economic analysis of biomass energy utilization through gasification technology for sustainable energy production and economic development in Nigeria. J Energy, 2018.

Rampe M J, Santoso I R S, Rampe H L, Tiwow V A, Rorano T E A. Study of pore length and chemical composition of charcoal that results from the pyrolysis of coconut shell in Bolaang Mongondow, Sulawesi, Indonesia. Karbala Int J Mod Sci, 2022; 8（1）.

Nsaful F, Görgens J F, Knoetze J H. Comparison of combustion and pyrolysis for energy generation in a sugarcane mill. Energy Conversion and Management, 2013; 74: 524–534.

Obileke K, Nwokolo N, Makaka G, Mukumba P, Onyeaka H. Anaerobic digestion: Technology for biogas production as a source of renewable energy—A review. Energy Environ, 2021; 32（2）: 191–225.

Amponsem B, Bensah E C, Antwi E, Ahiekpor J C, Boahen B, Mensah I, et al. Electricity generation from biogas as resource recovery potential from solid waste composition in a mixed-income municipality. Clean Waste Syst, 2023; 4: 100067.

Andersson J. Techno-economic analysis of integrated biomass gasification for green chemical production. ” BSc dissertation. Luleå: Luleå University of Technology, 2013; 84 p.

Arun K, Venkata Ramanan M, Mohanasutan S. Comparative studies and analysis on gasification of coconut shells and corn cobs in a perforated fixed bed downdraft reactor by admitting air through equally spaced conduits. Biomass Convers Biorefinery, 2022; 12（4）: 1257–1269.

Ahmad A A, Zawawi N A, Kasim F H, Inayat A, Khasri A. Assessing the gasification performance of biomass: A review on biomass gasification process conditions, optimization, and economic evaluation. Renew Sustain Energy Rev, 2016; 53: 1333–1347.

Vera D, de Mena B, Jurado F, Schories G. Study of a downdraft gasifier and gas engine fueled with olive oil industry wastes. App.Therm Eng, 2013; 51（1-2）: 119–129.

Aguado R, Vera D, Jurado F, Beltrán G. An integrated gasification plant for electric power generation from wet biomass: toward a sustainable production in the olive oil industry. Biomass Conv Bioref, 2022 .

Aguado R, Escámez A, Jurado F, Vera D. Experimental assessment of a pilot-scale gasification plant fueled with olive pomace pellets for combined power, heat and biochar production. Fuel, 2023; 344.

Basu P. Biomass gasification, pyrolysis and torrefaction. USA: Academic Press. 2018; doi: 10.1016/C2016-0-04056-1.

Peres A P G, Lunelli B H, Filho R M. Application of biomass to hydrogen and syngas production. Chemical Engineering Transactions, 2011; 32: 589–594.

Broer K M, Brown R C. The role of char and tar in determining the gas-phase partitioning of nitrogen during biomass gasification. Appl. Energy, 2015; 158: 474–483.

Fiore M, Magi V, Viggiano A. Internal combustion engines powered by syngas: A review. Applied Energy, 2020; 276: 115415.

Martínez J D, Mahkamov K, Andrade R V, Silva Lora E E. Syngas production in downdraft biomass gasifiers and its application using internal combustion engines. Renewable Energy, 2012; 38（1）: 1–9.

Baratieri M, Baggio P, Bosio B, Grigiante M, Longo G A. The use of biomass syngas in IC engines and CCGT plants: A comparative analysis. Applied Thermal Engineering, 2009; 29（16）: 3309–3318.

Scheiterle L, Birner R. Assessment of Ghana’s comparative advantage in maize production and the role of fertilizers. Sustainability, 2018; 10（11）.

GSS, “Population of regions and districity, ” Accra – Ghana, 2021; Available: https://statsghana.gov.gh/gssmain/fileUpload/pressrelease/2021%20PHC%20General%20Report%20Vol%203A_Population%20of%20Regions%20and%20Districts_181121.pdf. Accessed on: [2023-04-18].

Sawla-Tuna-Kalba. District profile. Available : http://sawlatunakalbadistrict.gov.gh/profile.html. Accessed on [2023-05-14].

Amonoo-Neizer O. Energy profile of districts in Ghana. 2019. Available: https://energycom.gov.gh/files/DISTRICT ENERGY PROFILE - Draft Final.pdf. Accessed on [2023-05-14].

Bonye S Z, Aasoglenang T A, Bebelleh Der F, Bobie C N, Dery G. Fulani herder-farmer conflicts in rural Ghana: Perspectives of communities in the Sawla-Tuna-Kalba District. Journal of Planning and Land Management, 2021; 2（1）: 77–86.

Pol Arranz P. Prospects of distributed electricity generation and services based on small scale biomass systems in ghana. PhD dissertation, Catalonia: Uniiversitat Polite’cnica De Catalunya, 2018; 93p.

Uresk D W. Cattle weights on USDA forest service lands by state with cow and calf forage consumption. Rangelands, 2010; 32（4）: 26–29.

USDA, Conservation Practice Standard Mulching. 2019; pp.2–4. Available: https://efotg.sc.egov.usda.gov/api/CPSFile/23082/484_NC_CPS_Mulching_2019. Accessed on [2023-05-14].

Mahdavi M, Jurado F, Schmitt K, Bayne S, Chamana M. Wheat agricultural residences for bioenergy generation in Morocco. In: 2023 IEEE IAS Global Conference on Renewable Energy and Hydrogen Technologies （GlobConHT）, Mali, Maldives: IEEE, 2023; pp.1–6. doi: 10.1109/GlobConHT56829.2023.10087643.

M. Mahdavi, A. Awaafo, K. Schmitt, F. Jurado and D. Vera, "Potential of Morocco in Energy Generation from Agricultural Residues, " 2023 IEEE International Conference on Environment and Electrical Engineering and 2023 IEEE Industrial and Commercial Power Systems Europe （EEEIC / I&CPS Europe）, Madrid, Spain, 2023, pp.1–6, doi: 10.1109/EEEIC/ICPSEurope57605.2023.10194876.

Chidikofan G, Benoist A, Sawadogo M, Volle G, Valette J, Coulibaly Y, et al. Assessment of environmental impacts of tar releases from a biomass gasifier power plant for decentralized electricity generation. Energy Procedia, 2017; 118: 158–163.

PIRSA. Calculating dry matter intakes for various classes of stock. 2019; Available: https://www.pir.sa.gov.au/__data/assets/pdf_file/0007/272869/Calculating_dry_matter_intakes.pdf. Accessed on [2023-05-14].

Kilama G, Lating P O, Byaruhanga J, Biira S. Quantification and characterization of cocoa pod husks for electricity generation in Uganda. Energy, Sustainability and Society, 2019; 9（1）.

Seglah P A, Neglo K A W, Wang H Y, Cudjoe D, Kemausuor F, Gao C Y, et al. Electricity generation in Ghana: Evaluation of crop residues and the associated greenhouse gas mitigation potential. Journal of Cleaner Production, 2023; 395: 136340.

Arranz-Piera P, Kemausuor F, Darkwah L, Edjekumhene I, Cortés J, Velo E. Mini-grid electricity service based on local agricultural residues: Feasibility study in rural Ghana. Energy, 2018; 153: 443–454.

Bationo A, Buerkert A, Sedogo M P, Christianson B C, Mokwunye A U. A critical review of crop-residue use as soil amendment in the West African semi-arid tropics. 1995; Available: https://agris.fao.org/search/en/providers/123819/records/64735df72c1d629bc97d35b5. Accessed on [2023-05-14].

Powell J M, Fernández-Rivera S, Williams T O, Renard C. Livestock and sustainable nutrient cycling in mixed farming systems of sub-Saharan Africa, In: Proceedings of an International Conference, Addis Ababa, Ethiopia: International Livestock Centre for Africa （ILCA）, 1993; pp.305–322. Available: https://www.fao.org/fileadmin/templates/agphome/images/iclsd/documents/wk1_c26_gerard.pdf. Accessed on [2023-05-14].

Wuni M. Assessment of the constraints in soybean production: A case of northern region, Ghana. Journal of Developments in Sustainable Agriculture, 2011; 6（2）: 199–214.

Lamidi A A, Ologbose F I. Dry season feeds and feeding: a threat to sustainable ruminant animal production in Nigeria. Journal of Agriculture and Social Research （JASR）, 2014; 14（1）: 17–31.

Hertel T W, Burke M B, Lobell D B. The poverty implications of climate-induced crop yield changes by 2030. Global Environmental Change, 2010; 20（4）: 577–585.

Das R. Poverty and hunger: causes and consequences. Sarup & Sons. 2006; Available: https://books.google.com.gh/books/about/Poverty_and_Hunger.html?id=Z6TcP7mj6cMC&redir_esc=y. Accessed on [2024-01-30]

Ankur Scientific biomass gasification system. Available: https://www.ankurscientific.com/. Accessed on [2024-01-30]

Spanner RE biomass gasification system. Available: https://www.caluweinc.com/products/spanner-re2/. Accessed on [2024-01-30]

Froeling biomass gasification system. Available: https://www.froeling.com/en-us/products/heat-and-electricity/chp/ /. Accessed on [2024-01-30]

All Power Labs biomass gasification system. Available: https://www.allpowerlabs.com/gasification-explained. Accessed on [2024-01-30]




Copyright (c) 2024 International Journal of Agricultural and Biological Engineering

Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 International License.

2023-2026 Copyright IJABE Editing and Publishing Office