Evaluation of droplet deposition and effect of variable-rate application by a manned helicopter with AG-NAV Guía system

Weixiang Yao, Yubin Lan, Sheng Wen, Huihui Zhang, Yali Zhang, Juan Wang, Chunchun Xie

Abstract


The variable-rate application is an important aspect of precision agriculture. In order to determine the regular patterns of droplet deposition and compare the actual variable-rate spraying effect of the AS350B3e helicopter with the AG-NAV Guía system, spray tests were conducted with different operating parameters and operating methods. In this study, the deposition distribution of droplets in the effective swath area was evaluated for six single-pass applications at four different flight velocities. The effects of adding adjuvant on droplet deposition, drift and droplet size were compared, and the actual variable effect of the forth-back application was verified. The analysis results showed that the position of the effective swath area was affected by natural wind velocity and wind direction, and would shift to the downwind direction area from the helicopter route of a different degree. The effective swath width increased slowly and then decreased sharply with the increase of flight velocity. It was found that flight velocity of 100 km/h was the peak inflection point of effective spray width variation. Moreover, the effect of flight velocity on the distribution uniformity of droplet deposition in the effective swath area was not significant. In the single-pass application of 90 km/h, adding adjuvant could increase droplet size in the effective swath area. The deposition increased by 8.98%, and the total drift decreased by 28.65%, of which the upwind drift decreased by 28.31% and the downwind drift decreased by 29.06%. In the forth-back application of 90 km/h, the error between actual application volume and system setting dose was 12%. The results of this study can provide valuable references for future research and practices on variable-rate aerial applications by manned helicopters.
Keywords: manned helicopter, precision agriculture, variable-rate aerial application, spray test, adjuvant, droplet deposition
DOI: 10.25165/j.ijabe.20191201.4039

Citation: Yao W X, Lan Y B, Wen S, Zhang H H, Zhang Y L, Wang J, et al. Evaluation of droplet deposition and effect of variable-rate application by a manned helicopter with AG-NAV Guía system. Int J Agric & Biol Eng, 2019; 12(1): 172–178.

Keywords


manned helicopter, precision agriculture, variable-rate aerial application, spray test, adjuvant, droplet deposition

Full Text:

PDF

References


Lan Y B, Thomson S J, Huang Y B, Hoffmann W C, Zhang H H. Current status and future directions of precision aerial application for site-specific crop management in the USA. Computers & Electronics in Agriculture, 2010; 74(1): 34–38.

Stevenj T, Huang Y B, Jamese H, Daniele M, Lowreya S. Improving flow response of a variable-rate aerial application system by interactive refinement. Computers & Electronics in Agriculture, 2010; 73(1): 99–104.

Xue X Y, Lan Y B. Agricultural aviation applications in USA. Transactions of the CSAM, 2013; 44(5): 194–201. (in Chinese)

Kirk I W, Tom H H. Precision GPS flow control for aerial spray applications. Precision Agriculture, 1996; 3: 815–817.

Smith L A. Automatic flow control for aerial application. Applied Engineering in Agriculture, 2000; 17(4): 449–455.

Thomson S J, Smith L A, Hanks J E. Evaluation of application accuracy and performance of a hydraulically operated variable-rate aerial application system. Transactions of the ASABE, 2009; 52(3): 715–722.

Smith L A, Thomson S J. GPS position latency determination and ground speed calibration for the SATLOC Airstar M3. Applied Engineering in Agriculture, 2005; 21(5): 769–776.

Koch B, Khosla R, Frasier W M, Westfall D G, Inman D. Economic feasibility of variable-rate nitrogen application utilizing site-specific management zones. Agronomy Journal, 2004; 96(6): 1572–1580.

McLeod I M, Lucarotti C J, Hennigar C R, MacLean D A, Holloway A G L, Cormier G A, et al. Advances in aerial application technologies and decision support for integrated pest management. Integrated Pest Management and Pest Control-Current and Future Tactics, 2012; pp.651–668.

Priddel D, Carlile N, Wilkinson I, Wheeler R. Eradication of exotic mammals from offshore islands in New South Wales, Australia. IUCN, 2011; pp.107–114.

Zhou Z Y, Zang Y, Luo X W, Lan Y B, Xue X Y. Technology innovation development strategy on agricultural aviation industry for plant protection in China. Transactions of the CSAE, 2013; 29(24): 1–10. (in Chinese)

Lan Y B. Agricultural applications of unmanned aerial vehicle. Zi Guangge, 2017; 1: 86.

Liu Y, Gu C Y. The airborne aeronautical chart assisting navigation system based on component GIS. Geomatics & Spatial Information Technology, 2009; 6: 87–89, 92. (in Chinese)

Lu Z H, Shen M X, Ji C Y. Channel planning and border algorithm in agricultural aircraft operating based on embedded and GPS technology. Journal of Anhui Agricultural, 2009; 8: 3819–3820, 3823. (in Chinese)

Xu X, Xu S, Liu Y X, Chen J S, Cai Z X, Yu Z S. Variable pesticide spraying system design based on small UAV. Guangdong Agricultural Sciences, 2014; 9: 207–210. (in Chinese）

Wang L, Lan Y B, Hoffmann W C, Bradley K F, Chen D, Wang S M. Design of variable spraying system and influencing factors on droplets deposition of small UAV. Transactions of the CSAM, 2016; 1: 15–22. (in Chinese)

Xue X Y, Lan Y B, Sun Z, Chang C, Hoffmann W C. Develop an unmanned aerial vehicle based automatic aerial spraying system. Computers & Electronics in Agriculture, 2016; 128: 58–66.

Huang W Z, Lin X A, Cao Q, Qin Y Y. Preliminary report on the experiment of spraying biological agents to control locust locus. Journal of Henan Forestry Science and Technology, 2006; 4: 16–18.

Zhong L, Qiu G H, Song J H, Shi J M, Xu F F, Zhu Q Q, et al. The effect of droplet deposition on the control of rice sheath blight. China Plant Protection, 2014; 8: 64–66. (in Chinese)

Yan R K, Wu N, Hu W J, Wang H E. Experimental report on the control of chromaphis juglandicola kaltenbach by R44Raven-Ⅱ type of helicopter. Journal of Green Science and Technology, 2016; 3: 4–6. (in Chinese)

Zhang D Y, Lan Y B, Chen L P, Wang X, Liang D. Current status and future trends of agricultural aerial spraying technology in China. Transactions of the CSAM, 2014; 45(10): 53–59. (in Chinese)

Zhang R R, Li Y, Yi T C, Chen L P. Design and experiments of control system of variable pesticide application for manned helicopter. Journal of Agricultural Mechanization Research, 2017; 10: 124–127. (in Chinese)

Lan Y B, Chen S D, Li J Y, Zhang Y L, Huang C, Yao W X, et al. Evaluation system of flying flight quality based on BeiDou locating system. Chinese Patent, CN205563277U.

MH/T Standards. 1050-2012: Field measurement methods for Aircraft spray drift, Beijing: MHT, 2012. (in Chinese)

Zhang D Y, Chen L P, Zhang R R, Xu G, Lan Y B, Wesley C H, et al. Evaluating effective swath width and droplet distribution of aerial spraying systems on M-18B and Thrush 510 G airplanes. Int J Agric & Biol Eng, 2015; 8(2): 21–30.

MH/T Standards. 1040-2011: Determining application rates and distribution patterns from aerial application equipment, Beijing: MHT, 2011. (in Chinese)

Zhu Y. Calculation of aerodynamic interactions between helicopter rotor and fuselage. Nanjing University of Aeronautics & Astronautics, 2007. (in Chinese)




Copyright (c) 2019 International Journal of Agricultural and Biological Engineering



2023-2026 Copyright IJABE Editing and Publishing Office