Numerical simulation and experimental verification on downwash air flow of six-rotor agricultural unmanned aerial vehicle in hover

Yang Fengbo, Xue Xinyu, Zhang Ling, Sun Zhu

Abstract


Recently, multi-rotor unmanned aerial vehicle (UAV) becomes more and more significantly irreplaceable in the field of plant protection against diseases, pests and weeds of crops. The easy takeoff and landing performance, hover function and high spraying efficiency of UAV are urgently required to spray pesticide for crop timely and effectively, especially in dispersed plots and hilly mountains. In such situations, the current researches about UAV spray application mainly focus on studying the influence of the UAV spraying parameters on the droplet deposition, such as operation height, operation velocity and wind velocity. The deposition and distribution of pesticide droplets on crops which depends on installation position of nozzle and airflow distribution characteristics of UAV are directly related to the control effect of pesticide and crop growth in different growth periods. As a preliminary step, this study focuses on the dynamic development law and distribution characteristics of the downwash air flow for the SLK-5 six-rotor agricultural UAV. Based on compressible Reynolds-averaged Navier-Stokes (RANS) equations with an RNG k-ε turbulence model and dynamic mesh technology, the efficient three-dimensional computational fluid dynamics (CFD) method was established to analyze the flow field distribution characteristics of UAV in hover. Then the unsteady interaction flow field of the wing was investigated in detail. The downwash wind speed of the marked points for the SLK-5 UAV in hover was also tested by weather tracker. It was found that the maximum velocity value of the downwash flow was close to 10 m/s; the z-direction velocity was the main body of the wind velocity in the downwash airflow, and the comparison of the wind velocity experiment test and simulation showed that the relative error was less than 12% between the experimental and simulated values of the z-direction velocity at the marked points. Then the flow characteristics of the longitudinal and cross section were analyzed in detail, the results obtained can be used as a reference for drift and sedimentation studies for multi-rotor unmanned aerial vehicle.
Keywords: UAV, downwash air flow, numerical simulation, experimental verification, pesticide spray, wing interference
DOI: 10.25165/j.ijabe.20171004.3077

Citation: Yang F B, Xue X Y, Zhang L, Sun Z. Numerical simulation and experimental verification on downwash air flow of six-rotor agricultural unmanned aerial vehicle in hover. Int J Agric & Biol Eng, 2017; 10(4): 41–53.

Keywords


UAV, downwash air flow, numerical simulation, experimental verification, pesticide spray, wing interference

Full Text:

PDF

References


Zhang B, Tang Q, Chen L P, Xu M. Numerical simulation of wake vortices of crop spraying aircraft close to the ground. Biosystems Engineering, 2016; 145: 52–64.

John H. Unmanned Flight: The Drones Come Home. National Geographic, March 2013.

Yang Y S, Zhang J P, Nie S L. Energy loss of nozzles in water jet system. J. Mech. Eng., 2013; 49(2): 139–145. (in Chinese).

Matthew G. Rise of the Ag Drones. Precision Agr. 2013; March 6.

Green M. Unmanned drones may have their biggest impact on agriculture. Daily Beast, 2013

Jenkins D, Bijan V. Association for Unmanned Vehicle Systems International. The economic impact of unmanned aircraft systems integration in the US. Robotics Tomorrow, 2013.

Xue X Y, Liang J, Fu X M. Prospects of China's aviation plant protection technology. Chinese Agricultural Mechanization, 2008; 5: 72–74. (in Chinese)

Xue X Y, Tu K, Qin W C, Lan Y B, Zhang H H. Drift and deposition of ultra-low altitude and low volume application in paddy field. Int. J. Agric. Biol. Eng., 2014; 7(4): 23–28.

Zhang W J, Jiang F B, Ou J F. Global pesticide consumption and pollution: with China as a focus. In: Proceedings of the International Academy of Ecology and Environmental Sciences, 2011; 1, pp. 125–144.

Sogawa K. The rice brown plant hopper: feeding physiology and host plant interactions. Annu. Rev. Entomol., 1982; 27(1): 49–73.

Xue X Y, Liang J, Fu X M. Prospect of aviation plant protection in China. Chin. Agric., 2008; 5: 72–74. (in Chinese)

Zhang D Y, Lan Y, Chen L P, Wang X, Liang D. Current status and future trends of agricultural aerial spraying technology in China. Transactions of the CSAM, 2014; 45(10): 53–59. (in Chinese)

Bae Y, Koo Y M. Flight attitudes and spray patterns of a roll-balanced agricultural unmanned helicopter. Appl. Eng. Agric., 2013; 29: 675–682.

Qin W C, Qiu B J, Xue X Y, Chen C, Xu Z F, Zhou Q Q. Droplet deposition and control effect of insecticides sprayed with an unmanned aerial vehicle against plant hoppers. Crop Prot., 2016; 85: 79–88.

Fritz B K, Hoffmann W C, Lan Y B. Evaluation of the EPA drift reduction technology (DRT) low-speed wind tunnel protocol. J. ASTM Int., 2009; 6: 102–129.

Hoffmann W C, Fritz B K, Lan Y B. Evaluation of a proposed drift reduction technology high-speed wind tunnel testing protocol. J. ASTM Int., 2009; 6: 102–122

Hilz E, Vermeer A W P. Spray drift review: the extent to which a formulation can contribute to spray drift reduction. Crop Prot., 2013; 44: 75–83.

Reed W H. An analytical study of the effect of airplane wake on the lateral dispersion of aerial sprays. Report 3032. Langley, VA, USA: National Advisory Committee for Aeronautics, 1953.

Xue X Y, Lan Y B. Agricultural Aviation Applications in USA. Transactions of the CSAM, 2013; 44(5): 194–201. (in Chinese)

Teske M E, Bilanin A J, Barry J W. Decay of aircraft vortices near the ground. AIAA Journal, 1993; 31(8): 1531–1533.

Teske M E, Bird S L, Esterly D M, Curbishley T B, Ray S L, Perry S G. AgDrift®: A model for estimating near-field spray drift from aerial applications. Environ. Toxicol. Chem., 2002; 21(3): 659–671.

Teske M E, Thistle H W, Schou W C, Miller P C, Strager J M, Richardson B, et al. A review of computer models for pesticide deposition prediction. Transactions of the ASABE, 2011; 54(3): 789–801.

Dumbauld R K, Bjorklund J R, Saterlie S F. Computer models for predicting aircraft spray dispersion and deposition above and within forest canopies: User's manual for the FSCBG computer program. Report 80e11. Davis, CA: U.S. Department of Agriculture Forest Service, 1980.

Teske M E, Thistle H W. Aerial application model extension into the far field. ASAE Annual Meeting, 2003.

Reed W H. An analytical study of the effect of airplane wake on the lateral dispersion of aerial sprays. Report 3032. Langley, VA, USA: National Advisory Committee for Aeronautics, 1953.

Craig I P. The GDS model—a rapid computational technique for the calculation of aircraft spray drift buffer distances. Comput. Electron. Agr., 2004; 43(3): 235–250.

Bartzanas M T, Zhu H. Karmakar S, Tamimi E, Katsoulas N, et al. Computational fluid dynamics applications to improve crop production systems. Comput. Electron. Agr., 2013; 93: 151–167.

Brown R B, Sidahmed M M. Simulation of spray dispersal and deposition from a forestry airblast sprayer. Part II: droplet trajectory model. Trans. ASAE, 2001; 44(1): 11–17.

Nuyttens D, De Schampheleire M. Baetens K, Brusselman E, Dekeyser D, Verboven P. Drift from field crop sprayers using an integrated approach: results of a five-year study. Transactions of the ASABE, 2011; 54(2): 403–408.

Molari G, Benini L, Ade G. Design of a recycling tunnel sprayer using CFD simulations. Trans. ASAE, 2005; 48(2): 463–468.

Tsay J, Ozkan H E, Brazee, R D, Fox R D. CFD simulation of moving spray shields. Trans. ASAE, 2002; 45(1): 21–26.

Reichard D L, Zhu H, Fox R D, Brazee R D. Computer simulation of variables that influence spray drift. Trans. ASAE, 1992; 35(5): 1401–1407.

Zhu H, Reichard D L, Fox R D, Brazee R D, Ozkan H E. Simulation of drift of discrete sizes of water droplets from field sprayers. Trans. ASAE, 1994; 37(5): 1401–1407.

Zhu H, Richard D L, Fox R D, Brazee R D, Ozkan H E. Collection efficiency of spray droplets on vertical targets. Trans. ASAE, 1996; 39(2): 415–422.

Ryan S D, Gerber A G., Holloway A. A computational study on spray dispersal in the wake of an aircraft. Transactions of the ASABE, 2013; 56(3): 847–868.

Zhang S C, Xue X Y, Qin W C, Sun Z, Ding S M, Zhou L X. Simulation and experimental verification of aerial spraying drift on N-3 unmanned spraying helicopter. Trans. CSAE, 2015; 31(3): 87–93. (in Chinese)

Alderete T S. Simulator Aero Model Implementation. NASA Ames Research Center, Moffett Field, California, 1995.

ETKIN. B. Dynamics of Flight. New York: John Wiley and Sons, INC, 1959.

Roberts T W, Murman E M. Solution method for a hovering helicopter roter using the Euler equations. AIAA 85-0436, 1985.

Pomin H, Wagner S. Navier-Stokes analysis of helicopter rotor aerodynamics in hover and forward flight. AIAA 2001-0998, 2001.

Orszag S A, Yakhot V, Flannery W S. Renormalization group modeling and turbulence, in international conference on near wall turbulence flows. 1993.




Copyright (c)



2023-2026 Copyright IJABE Editing and Publishing Office