Air flow characteristics of an air-assisted sprayer through horizontal crop canopy

Pankaj Gupta, N. P. S. Sirohi, I.M. Mishra

Abstract


Abstract: Artificially induced air currents or air-assistance to droplet spectrum produced by hydraulic nozzles not only facilitate in transporting and depositing the droplets in different parts of canopy but also reduce the application rate of chemicals. The air streams increase the velocity of smaller droplets so that extra momentum would increase impaction and improve penetration into the crop as well as mitigating the influence of wind on drift. It is necessary to quantify the airflow characteristics. But, control of climatic and other conditions in the field is very difficult. Thus, airflow characteristics study was done under controlled conditions on a horizontal simulated crop canopy. Based on this study, an airflow distribution model was developed and airflow characteristics for vegetable crops, namely, eggplant, chilli and bittergourd were predicted. The differences between predicted and actual field study values were not statistically significant. Kinetic energy of air stream dissipated with its movement from top to bottom of the canopy. The rate of kinetic energy dissipation was higher in denser canopies. Higher air velocity 15 m/s was the best as it produced maximum turbulence throughout the canopy.
Keywords: air assisted sprayer, simulated crop canopy, air velocity
DOI: 10.3965/j.ijabe.20120501.001

Citation: Pankaj Gupta, Sirohi N P S, Mishra I M. Air flow characteristics of an air-assisted sprayer through horizontal crop canopy. Int J Agric & Biol Eng, 2012; 5(1): 1

Keywords


air assisted sprayer, simulated crop canopy, air velocity

Full Text:

Provisional-PDF PDF

References


Cooke B K, Hislop E C, Herrington P J, Western N M,

Humpherson J F. Air-assisted spraying of arable crops, in

relation to deposition, drift and pesticide performance. Crop

Protection, 1990; 9(4): 303-311.

Franklin T G, O'Brien R G, Banks A G. Performance of

two methods of boom spray application. In: Conference on

agricultural engineering, Adelaide, Australia, 24-28 August,

Preprints of papers. 101-105; National Conference

Publication No.86-9.

Reed J P, Hall F R, Riedel R M. Biological implications of

drift from sprayers in tomato fungicide field trials. Plant

Disease, 1993; 77(2): 186-189.

Ade G, Rondelli V. Performance of an air-assisted boom

sprayer in the control of Colorado beetle infestation in potato

crops. Bio System Engineering, 2007; 97: 181 –187.

Womac A R, Mulrooney J E, Scott W P. Characteristics of

air-assisted and drop-nozzle sprays in cotton. Transactions

of the ASAE, 1992; 35(5): 1369-1376.

Ade G, Pezzi F, Cooper S E, Taylor W A, Cross J V, Gilbert

A J et al. The influence of some application variables on

spray deposition in field-grown tomatoes. Pesticide

application, University of Surrey, Guildford, UK, 17-18

January 2000. Aspects of Applied Biology, 2000; 57:

-233.

Bhargav V K. Design, development and evaluation of

air-assisted boom sprayer for orchard application.

Unpublished. Ph.D. Thesis, 2001; IARI, New Delhi.

Balsari P, Marucco P. Influence of canopy parameters on

spray drift in vineyard. Aspects of Applied Biology, 2004;

(1): 157-164.

Bauer F C, Raetano C G. Effect of air assistance on

deposition and losses of pesticides sprayed on soyabeans.

Scientia Agricola, 2000; 57(2): 271-276.

Nordbo E. Effects of nozzle size, travel speed and air

assistance on deposition on artificial vertical and horizontal

targets in laboratory experiments. Crop Protection, 1992;

(3): 272-278.

Walklate P J, Weiner K L, Parkin C S. Analysis of and

experimental measurement made on moving air assisted

sprayer with two dimensional air jets penetrating a uniform

artificial crop canopy. J. Agric. Engg. Res., 1996; 63:

-378.

Gupta P, Sirohi N P S, Rengasamy S, Vidhu K P. Effect

of air-assistance, leaf area density and forward speed on

spray deposition in simulated crop canopy. Journal of

Agricultural Engineering, 2004; 41(2); 25-30.

Sirohi N P S, Gupta P, Mani I. Development of air-assisted

hydraulic sprayer for vegetable crops. Journal of Institution

of Engineers, 2008; 89: 18-23.




Copyright (c)



2023-2026 Copyright IJABE Editing and Publishing Office