Effect of wind field below unmanned helicopter on droplet deposition distribution of aerial spraying

Chen Shengde, Yubin Lan, Li Jiyu, Zhou Zhiyan, Liu Aimin, Mao Yuedong

Abstract


Abstract: Wind field is one of the important factors affecting the distribution characteristics of aerial spraying droplet deposition. In order to reveal the impact mechanism of droplet deposition distribution by the wind field below agricultural unmanned helicopter rotor, in this study, the wind field distribution below uniaxial single-rotor electric unmanned helicopter rotor was measured by using a wireless wind speed sensor network measurement system for unmanned helicopter. The effects of wind field in three directions (X, Y, Z) below the rotor on droplet deposition distribution were analyzed with the condition of aerial spraying droplet deposition in rice canopy, and the regression model was established via variance and regression analyses of experiment results. The results showed that, the wind field in Y direction had a significant effect on droplet deposition in effective spray area, the wind field in Z direction had an extremely significant effect on droplet deposition in effective spray area, and the corresponding significance (sig.) values were 0.011 and 0.000. Furthermore, the wind field in Z direction had a significant effect on the penetrability and uniformity of droplet deposition in effective spray area, the corresponding sig. values were 0.025 and 0.011 respectively. The wind speed in Y direction at the edge of effective spray area had a significant effect on droplet drift, the sig. value was 0.021. In addition, the correlation coefficient R of the regression model was 0.869 between droplet deposition in effective spray area and the wind speed in Y and Z directions, and 0.915 between the uniformity of droplet deposition in effective spray area and the maximum wind speed in Z direction. The result revealed the influencing mechanism of the wind field below the rotor of uniaxial single-rotor electric unmanned helicopter on the distribution of aerial spraying droplet deposition. The results can provide guidance for the actual production application of aerial spraying to reduce liquid drift and improve the utilization rate of pesticide.
Keywords: uniaxial single-rotor electric unmanned helicopter, aerial spraying, wind field, droplet deposition
DOI: 10.3965/j.ijabe.20171003.3078

Citation: Chen S D, Lan Y B, Li J Y, Zhou Z Y, Liu A M, Mao Y D. Effect of wind field below unmanned helicopter on droplet deposition distribution of aerial spraying. Int J Agric & Biol Eng, 2017; 10(3): 67–77.

Keywords


uniaxial single-rotor electric unmanned helicopter, aerial spraying, wind field, droplet deposition

Full Text:

PDF

References


Xue X Y, Tu K, Qin W C, Lan Y B, Zhang H H. Drift and deposition of ultro-low altitude and low volume application in paddy field. Int J Agric & Biol Eng, 2014; 7(4): 23–28.

Wang Y Q. Analysis on the occurrence and development of rice diseases and insects in China. Chinese Agricultural Science Bulletin, 2006; 22(2): 343–347. (in Chinese)

Li B, Liu Z Y, Huang J F, Zhang L L, Zhou W, Shi J J. Hyperspectral identification of rice diseases and pests based on principal component analysis and probabilistic neural network. Transactions of the CSAE, 2009; 25(9): 143–147. (in Chinese)

Wang C L, He X K, Wang X N, Bonds J, Herbst A, Wang Z G. Testing method of spatial pesticide spraying deposition quality balance for unmanned aerial vehicle. Transactions of the CSAE, 2016; 32(11): 54–61. (in Chinese)

Yang X J, Yan H R, Xu S Z, Liu Z. Current situation and development trend of equipment for crop protection. Transactions of the CSAM, 2002; 33(6): 129–131. (in Chinese)

Wang Z G, Lan Y B, Hoffmann W C, Wang Y H, Zheng Y J. Low altitude and multiple helicopter formation in precision agriculture. ASABE Annual International Meeting, Paper No. 131618681, 2013, Presented at Kansas City, MO, USA.

Giles D, Billing R. Deployment and performance of an unmanned aerial vehicle for spraying of specialty crops. International Conference of Agricultural Engineering, Zurich, 2014, 7, C0589.

Huang Y B, Hoffmann W C, Lan Y B, Wu W, Fritz B K. Development of a spray system for an unmanned aerial vehicle platform. Applied Engineering in Agriculture, 2009; 25(6): 803–809.

Xue X Y, Lan Y B, Sun Z, Chang C, Hoffmann W C. Development an unmanned aerial vehicle based automatic aerial spraying system. Computers and electronics in agriculture, 2016; 128: 58–66.

Huang Y B, Thomson S J, Hoffmann W C, Lan Y B, Fritz B K. Development and prospect of unmanned aerial vehicle technologies for agricultural production management. Int J Agric & Biol Eng, 2013; 6(3): 1–10.

Chen S D, Lan Y B, Li J Y, Zhou Z Y, Jin J, Liu A M. Effect of spray parameters of small unmanned helicopter on distribution regularity of droplet deposition in hybrid rice canopy. Transactions of the CSAE, 2016; 32(17): 40–46. (in Chinese)

Zhu H, Lan Y B, Wu W F, Hoffmann W C, Huang Y B, Xue X Y, Liang J, Fritz B K. Development of a PWM precision spraying controller for unmanned aerial vehicles. Journal of Bionic Engineering, 2010; 7(3): 276–283.

Qin W C, Qiu B J, Xue X Y, Chen C, Xu Z F, Zhou Q Q. Droplet deposition and control effect of insecticides sprayed with an unmanned aerial vehicle against plant hoppers. Crop Protection, 2016; 85: 79–88.

Zhang D Y, Chen L P, Zhang R R, Xu G, Lan Y B, Hoffmann W C, et al. Evaluating effective swath width and droplet distribution of aerial spraying systems on M-18B and Thrush 510G airplanes. Int J Agric & Biol Eng, 2015; 8(2): 21–30.

Thomson S J, Womac A R, Mulrooney J E. Reducing pesticide drift by considering propeller rotation effects from aerial application and near buffer zones. Sustainable Agriculture Research, 2013; 2(3): 41–51.

Fritz B K, Hoffmann W C, Lan Y B. Evaluation of the EPA drift reduction technology (DRT) low-speed wind tunnel protocol. Journal of ASTM International, 2010; 6(4): 1–11.

Hoffmann W C, Fritz B K, Lan Y B. Evaluation of a proposed drift reduction technology high-speed wind tunnel testing protocol. Journal of ASTM International, 2009; 6(4): 1–11.

Teske M E, Barry H W. Aerial Spray Drift Modeling. P. Zanetti (Ed.) Environmental Modeling Vol.Ⅱ: Computer methods and software for simulating environmental pollution and its adverse effect. Computational Mechanics Publications, 1994.

Zhang S C, Xue X Y, Qin W C, Sun Z, Ding S M, Zhou L X. Simulation and experimental verification of aerial spraying drift on N-3 unmanned spraying helicopter. Transactions of the CSAE, 2015; 31(3): 87–93. (in Chinese)

Baetens K, Nuyttens D, Verboven P, Schampheleire M D, Nicolai B, Ramon H. Predicting drift from field spraying by means of a 3D computational fluid dynamics model. Computers and Electronics in Agriculture, 2007; 56(2): 161–173.

Hu L, Zhou Z Y, Luo X W, Wang P, Yan Y A, Li J Y. Development and experiment of a wireless wind speed sensor network measurement system for unmanned helicopter. Transactions of the CSAM, 2014; 45(5): 221–226. (in Chinese)

Wang P, Luo X W, Hu L, Zhou Z Y, Lan Y B, Zang Y. Wind field measurement for supplementary pollination using two types unmanned helicopter in hybrid rice breeding. ASABE Annual International Meeting, Paper No. 131592053, 2013, Presented at Kansas City, MO, USA

Zhu H P, Salyani M, Fox R D. A portable scanning system for evaluation of spray deposit distribution. Computers and Electronics in Agriculture, 2011; 76: 38–43.

MH/T Standards 1008-1997: The technical indices of the distributing performance of the aircraft distribution equipments, Beijing: MHT.

Wang J. Experimental design and SPSS application. Beijing: Chemical industry Press, 2006.

MH/T Standards 1002-1995: The operative indices of quality and techniques of agriculture and forestry aviation, Beijing: MHT.

Li J Y, Zhou Z Y, Hu L, Zang Y, Yan M L, Liu A M, et al. Optimization of operation parameters for supplementary pollination in hybrid rice breeding using uniaxial single-rotor electric unmanned helicopter. Transactions of the CSAE, 2014; 30(10): 10–17. (in Chinese)

Li J Y, Zhou Z Y, Hu L, Zang Y, Xu S, Liu A M, et al. Optimization of operation parameters for supplementary pollination in hybrid rice breeding using round multi axis multi-rotor electric unmanned helicopter. Transactions of the CSAE, 2014; 30(11): 1–9. (in Chinese)




Copyright (c)



2023-2026 Copyright IJABE Editing and Publishing Office