Surface characteristics of microalgae and their effects on harvesting performance by air flotation

Wen Hao, Li Yanpeng, Shen Zhou, Ren Xiangying, Zhang Wenjun, Liu Jun

Abstract


Flotation is considered as an effective and energy efficient method for harvesting microalgae. However, the interaction mechanism between bubble-algae cell and cell-cell interfacial boundaries in microalgae flotation is not completely clear. To better understand the effects of surface characteristics on microalgae flotation performance, the hydrophobicity and the zeta potential of two different microalgae species were quantified based on experimental measurements and the extended DLVO (Derjagin–Landau–Verwey–Overbeek) theory. Flotation experiments were then carried out and the effects of surface characteristics on microalgae flotation performance were analyzed. Algae Chlorella vulgaris and Anabaena vasriabilis show naturally hydrophilic and hydrophobic properties, respectively. The addition of a cationic surfactant (C16TAB) can modify hydrophilic microalgae cells into hydrophobic and further Chlorella hydrophobicity is enhanced with increased C16TAB concentrations. The zeta potentials of both algae strains are negative in the tested pH range. Compared with Chlorella vulgaris, the magnitude of zeta potential of Anabaena vasriabilis is found larger at the same pH, resulting in a more dispersed distribution in the suspension. In addition, flotation experiments demonstrated that microalgae hydrophobicity and zeta potential have significant impacts on the harvesting efficiency and concentration factor. The hydrophobic attraction is found to play a more important role in determining the harvesting performance than electrostatic repulsion between the interacting surfaces, especially for hydrophobicity algae in the present study. Finally, the highest flotation efficiency and the highest concentration factor could not be concurrently obtained for both algae strains, suggesting that optimized flotation conditions should be selected as a compromise.
Keywords: microalgae, air flotation, harvesting performance, surface characteristics, zeta potential, hydrophobicity
DOI: 10.3965/j.ijabe.20171001.2698

Citation: Wen H, Li Y P, Shen Z, Ren X Y, Zhang W J, Liu J. Surface characteristics of microalgae and their effects on harvesting performance by air flotation. Int J Agric & Biol Eng, 2017; 10(1): 125–133.

Keywords


microalgae, air flotation, harvesting performance, surface characteristics, zeta potential, hydrophobicity

Full Text:

PDF

References


Formighieri C. Biodiesel from microalgae: Springer International Publishing, 2015: 2827–2839.

Walker T L, Purton S, Becker D K, Collet C. Microalgae as bioreactors. Plant Cell Reports, 2006; 24(11): 629–41.

Danquah M K, Gladman B, Moheimani N, Forde G M. Microalgal growth characteristics and subsequent influence on dewatering efficiency. Chemical Engineering Journal, 2009; 151(1-3): 73–78.

Zhang H Y, Liu C H, Kuang Y L, Lin J. Research on harvesting energy microalgae via foam flotation. Renewable Energy Resources, 2016; 34: 268–273.

Grima E M, Belarbi E H, Fernández F G A, Medina A R, Chisti Y. Recovery of microalgal biomass and metabolites: process options and economics. Biotechnology Advances, 2003; 20(7-8): 491–515.

Uduman N, Qi Y, Danquah M K, Forde G M, Hoadley A. Dewatering of microalgal cultures: A major bottleneck to algae-based fuels. Journal of Renewable & Sustainable Energy, 2010; 2(1): 389–392.

Suo M, Hongshan C. The application of biological agent in mineral processing. Metallic Ore Dressing Abroad, 2000; 11(3): 10–12.

Li Y, Yang L, Zhu T, Yang J, Ruan X. Biosurfactants as alternatives to chemosynthetic surfactants in controlling bubble behavior in the flotation process. Journal of Surfactants & Detergents, 2012; 16(3): 409–419.

Wu Z, Yi Z, Huang W, Zhang C, Li T, Zhang Y, et al. Evaluation of flocculation induced by pH increase for harvesting microalgae and reuse of flocculated medium. Bioresource Technology, 2012; 110(2): 496–502.

Prochazkova G, Safarik I, Branyik T. Harvesting microalgae with microwave synthesized magnetic microparticles. Bioresource Technology, 2012; 130C(1): 472–477.

Coward T, Lee J G M, Caldwell G S. Development of a foam flotation system for harvesting microalgae biomass. Algal Research, 2013; 2(2): 135–144.

Ozkan A, Berberoglu H. Physico-chemical surface properties of microalgae. Colloids & Surfaces B Biointerfaces, 2013; 112(6): 287–293.

Garg S, Wang L, Schenk P M. Effective harvesting of low surface-hydrophobicity microalgae by froth flotation. Bioresource Technology, 2014; 159(2): 437–441.

Coward T, Lee J G M, Caldwell G S. Harvesting microalgae by CTAB-aided foam flotation increases lipid recovery and improves fatty acid methyl ester characteristics. Biomass & Bioenergy, 2014; 67(9): 354–362.

Andersen R A. Algal culturing techniques. Elsevier Academic Press Oxford, 2005: pp. 450.

Prochazkova G, Podolova N, Safarik I, Zachleder V, Branyik T. Physicochemical approach to freshwater microalgae harvesting with magnetic particles. Colloids & Surfaces Biointerfaces, 2013; 112(3): 213–218.

Mittal K L. Contact angle, wettability and adhesion. CRC Press, 2006.

Ouyang Z R, Wen X B, Geng Y H, Mei H, Hu H J, Zhang G Y, et al. The effects of light intensities, temperatures, pH and salinities on photosynthesis of Chlorella. Plant Science Journal 2010; 28(1): 49–55.

Chen J C, Wang J, Qiu L P, Meng S L, Fan L M, Song C. Effect of pH on growth and competition of Chlorella vulga and Anabaena sp. strain PCC. Ecology and Environmental Sciences, 2014: 316–320.

Banerjee A, Sharma R, Chisti Y, Banerjee U C. Botryococcus braunii: A renewable source of hydrocarbons and other chemicals. Critical Reviews in Biotechnology, 2008; 22(3): 245–79.

Eroglu E, Melis A. Extracellular terpenoid hydrocarbon extraction and quantitation from the green microalgae Botryococcus braunii var. Showa. Bioresource Technology, 2010; 101(7): 2359–2366.

Stumm W, Morgan J J. Aquatic chemistry: chemical equilibria and rates in natural waters. John Wiley & Sons, 2012.

Callow M E, Callow J A, Ista L K, Coleman S E, Nolasco AC, López G P. Use of self-assembled monolayers of different wettabilities to study surface selection and primary adhesion processes of green algal (Enteromorpha) zoospores. Applied & Environmental Microbiology, 2000; 66(8): 3249–3254.

Niecikowska A, Zawala J, Malysa K. Influence of adsorption of n-alkyltrimethylammonium bromides (C8, C12, C16) and bubble motion on kinetics of bubble attachment to mica surface. Ciência E Tecnologia De Alimentos, 2011; 30(1): 68–75.

Piñeres J, Barraza J. Energy barrier of aggregates coal particle–bubble through the extended DLVO theory. International Journal of Mineral Processing, 2011; 100(1): 14–20.

Zhao Y, Li Y P, Huang J, Wang W K. Rebound and attachment involving single bubble and particle in the separation of plastics by froth flotation. Separation and Purification Technology 2015; 144: 123–132.




Copyright (c)



2023-2026 Copyright IJABE Editing and Publishing Office